宝洁安全培训教材讲解.ppt

Construction Safety施工安全;1.施工安全方针1.Construction Safety Policy;2.PG 安全工作程序2.PG Work Procedure of Safety;3.Entering site3.进入现场;现场紧急逃生及报警. On-site emergency escape call. 警报 集合点 清点人数 Alarm Assembly Area Personnel checking 报警电话:火警119;急救120;匪警110;宝洁火警电话5000 Emergency call:Fire119;First-aid120;Police110; PG fire call:5000 急救箱和急救员 First-aid kit first aid personnel; 现场紧急疏散计划 On-site emergency escape plan;零事故 7;零事故 8; ;零事故 10;零事故 11;零事故 12;零事故 13;6.防火6.Fire Prevention; 气瓶应竖立放置,气瓶间距不得小于6米,距明火不得小于10米 Gas cylinder should be kept upright always, distances among cylinders should not be less than 6m while distance from cylinder to fire is kept 10m at least 清除附近易燃物 Remove combustible materials from the immediate area. ;7. 压缩气瓶7. Compressed Gas Cylinders;8. 高空坠落的预防8. Fall Prevention; 在有过头顶作业时,须设立3米半径范围的围挡.除授权者外任何人不允许进入该区域 A three (3) meter radius shall be roped off around any overhead work. No person shall enter the roped off area except authorized personnel required for work in the area. 任何可产生坠落的边缘应有防护栏杆，并外挂密目安全网封闭 Railing and closed safety mesh should be applied at any possible falling edge 任何可产生坠落的边缘不得堆放物料,避免物料掉落伤人 No piling materials on any edge may cause falling to avoid hit of objects. ;9. 上牌和挂锁9. Lockout Tagout;10. 机械安全10. Machinery Safety;11. 电器安全11. Electrical Safety;电器设备只能由受过培训并合格的专业人员来操作。 Only trained and certified person can operate and repair the electrical devices. 季度检查 Quarterly inspection 用旧的和被损坏的设备必须报告给管理员 Employees are required to report damaged and defective tools to their supervisor. 电线使用时必须高挂2.5米 The cable shall be elevated 2.5m when it is under the use ;12. 密闭空间12. Confined Space;13. 脚手架13. Scaffolds;14. 梯子14. Ladders;15. 索具/起重 操作15. Rigging/Lifting Operation;16. 危险材料16. Hazardous Materials;17. 标记和标签17. Signs and Tags;18. 文明施工18. House Keeping;19. 安全行为观察19. BOS;20. 违反安全惩罚措施