水溶液中甲苯分散相增强难溶气体吸收.PDFVIP

2006 7 23 4 July 2006 CHEMICAL INDUS RY AND ENGINEERING Vol. 23 No. 4 : 1004- 9533(2006) 04- 0291- 06 霍霄鹏, 许春建, 张 丹, 林 成, 周 明 ( , 300072) : 利用难溶气体的物理吸收过程, 在具有恒定气液界面面积的吸收装置中研究了常压和 温 条件下分散液相( 甲苯) 对气液传质的增强作用通过测定气相( 丙烷和氢气) 压力随时间的变化, 计算出液侧传质系数和传质增强因子试验发现, 当传质组分在分散液相与连续液相内的分配系 数较大, 或在两相间的相对扩散系数较大, 且分散相形成的液滴较小时, 加入分散液相可显著增强 气液传质; 增强因子随分散液相含率的增大而增大, 但增大幅度逐渐减小; 当气体在纯水中的传质 系数增大时, 同等条件下分散相对气液传质的增强作用减小 : 吸收; 增强; 增强因子; 甲苯; 丙烷; 氢气 : Q0214 :A Sparingly Soluble Gases Physical Absorption Enhanced by Presence of Dispersed Toluene Droplets in Water HUO Xiaopeng, XU Chunjian, ZHANG Dan, LIN Cheng, ZHOU Ming ( Chemical Engineering Research Centre, ianjin University, ianjin 300072, China) Abstract: In thiswork, the enhancement of gasliquid mass transfer was studied under the normal pressure and at normal temperature with the presence of the dispersed liquid phase(toluene) by using the sparingly soluble gases( propane and hydrogen) physical absorption process. he mass transfer coefficient and mass transfer enhancement factor can be calculated by measuring the variation of gas(propane and hydrogen) pressure versus time. he result shows that the enhancement factor increases significantly with the presence of the dispersed phase in the condition of the mass transfer component possessing larger partition coefficient in continuous phase and dispersed phase or possessing larger relative diffusion coefficient with the dispersed phase dispersed with finely droplets. Enhancement factor increases with volumetric fraction of dispersed phase increasing, but the gradient becomes smal