益母草颗粒的生产工艺.docVIP

摘要本设计为年产生产工艺设计，制备过程，设备选型，料衡算。根据设备的型号进行车间设备的布置，最后介绍了安全生产、环保与三废处理。关键词：工艺流程ABSTRACT Motherwort has the blood to regulate menstruation, swelling of the diuretic effect. In addition, for irregular menstruation, dysmenorrhea, amenorrhea, lochia, edema, oliguria; acute nephritis edema. Motherwort particle effect mainly on the role of the uterus, anti-platelet aggregation, on the cardiovascular, respiratory central role of gastrointestinal smooth muscle, kidney regulation. Motherwort research by people, the system got Motherwort particles.  This is designed to produce ten million bags of grain production process design Motherwort, Leonurus first introduced the role of efficacy, trait, clinical uses, dosage and adverse reactions. Motherwort particles prepared by master process, equipment selection, and depending on the device model for the mass balance and thermal material accountancy. Completed the process with a control point map, workshop layout, plant layout, the main equipment diagram. Depending on the model and the plant equipment layout, and finally introduced the production safety, environmental protection and waste treatment. 显示对应的拉丁字符的拼音 Keywords: Motherwort Granule； Process； Equipment Selection； Material balance 第一章绪论 引言益母草颗粒为月经不调类非处方药药品 汉语拼音:yimucao keli 规 格 ：每袋装15克 剂 型：颗粒剂 包装规格:15g×20袋 贮 藏:密封 1.2.2性状 本品为临床用途第二章的生产工艺 的生产工艺。 10g 蔗糖 g 糊精 2g 2.2益母草颗粒的生产工艺设计 2.2.1.6操作间相对温度控制在45%-65%之间。 2.2.1.7分装前核对品名、数量、批号、中间产品合格证并校对领用的包装材料，校正衡量器具并贴有合格证，确认无误后才能开机分装。 2.2.1.8内包装采用复合膜，每袋装15g。 2.2.1.9产品批号采用押印直接打印在封口处，打印清晰，准确无误。 2.2.2.0中包装 2.2.2.1包装规格15g×20袋，数量要准确无误，每中盒放一张说明书，中盒用封口签封口。 2.2.2.2生产日期、有效期及产品批号应按规定位置喷码清晰，准确无误。 大包装 2.2.2.3每50中盒为一件，并附合格证（装箱单），每件上下放一张缓冲垫板。 2.2.2.4纸箱上的产品批号、生产日期、有效期应印字清晰，准确无误。 2.2.2.5纸箱开口处用胶带密封，并用两条包装带捆扎，两条包装带离纸箱两端距离基本相等，约15cm。 2.3益母草颗粒的生产工艺流程图: 原料净选 3小时 至相对密度为1.04（90-95℃）